SYD-387深色石油产品硫含量试验器操作说明书.doc

SYD-387深色石油产品硫含量试验器操作说明书

8
2020年5月29日
文档仅供参考

SYD-387
深色石油产品硫含量试验器

使 用 说 明 书

GLMGS

06月06日

一、产品简介
One, product introduction
SYD-387深色石油产品硫含量试验器(管式炉法) 是根据国家标准GB/T387<深色石油产品硫含量测定法(管式炉法)>规定的要求设计制造的,适用于测定深色石油产品中的硫含量。本仪器经过装有试样的石英舟,在定流量的净化的高温热空气气流中进行完全燃烧,用过氧化氢和硫酸的溶液,将生成的亚硫酸酐和硫酸酐充分吸收,生成的硫酸用氢氧化钠标准溶液进行滴定。
SYD-387dark sulfur in petroleum products ( tubular oven method ) is based on the national standard GB / T387" dark petroleum products - Determination of sulphur content ( tubular oven method" ) in accordance with the requirements of the design and manufacture, applied in the determination of sulfur content in petroleum products dark. The apparatus through a sample of quartz boat, in the constant flow of high temperature hot air purification for complete combustion, hydrogen peroxide and sulfuric acid solution, will generate the sulphurous acid anhydride and sulfuric anhydride fully absorbed, generation of sulfuric acid with sodium hydroxide standard solution titration.
二、技术指标
Two, technical indicators
★使用电源: AC 220V±10% 50Hz;
In use of power: AC220V + 10% 50Hz;
★加热炉型式与数量:水平型并列双管管式电阻炉;
Of heating furnace type and quantity : horizontal type double-tube parallel tube type resistance furnace;
★电阻炉炉膛直径:Φ22mm;
Of resistance furnace: <22mm in diameter;
★电阻炉加热功率:1400W×2;
Of resistance furnace heating power:1400W x 2;
★电阻炉最高使用温度:950℃;
Of resistance furnace: maximum use temperature of950 DEG c;
★电阻炉移动距离:不小于135mm;
Of resistance furnace moving distance: not less than 135mm;
★供气流量:不小于150L/h;
Of gas flow: not less than 150L / h;
★时间设定最大值:99分59秒(100min)。
Set the maximum of time:99minutes and 59 seconds (100min ).
三、产品特点
Three, product characteristics
★本仪器主要由管式炉﹑炉温控制仪﹑空气流量指示装置、显示装置等部分组成。
Of the instrument is mainly composed of tubular furnace, a furnace temperature control system, air flow indicating device, display device and other components.
★采用单片机组成智能控制系统,检测时间、炉体移动、到时报警等功能实现自动控制。
The intelligent control system of single chip microcomputer, detection time, furnace body movement, and alarm functions to realize the automatic control.
★按要求设置好炉体移动方式后,仪器按照试验程序的要求,炉体会自动移动、自动停止和自动返回初始工作状态。
According to the requirements set up of furnace body moves, apparatus according to the test program requirements, furnace, automatic stop automatic mobile experience and automatic return to original state.
★本仪器设计有水平型并列双管管式电阻炉,可同时对2个试样进行试验,试验效率高,试验结果准确可靠。
In the apparatus design level of double tube type resistance furnace, simultaneously on the2samples are tested, the test efficiency is high, the test results are accurate and reliable.
★设有内置供气装置和外接气源接口,能够使用内部气源,也能够使用外部气源
Of which is internally provided with a gas supply device and the external air source interface, you can use the internal source, can also use external source
四、仪器成套
In four, complete sets of equipment
★管式炉硫含量试验器
Tube type furnace of sulfur in
★电源线(自制)
Of power line ( homemade)
★无阀洗气瓶,250mL
Of valveless gas washing bottle,250mL
★有阀洗气瓶,250mL
U have valve gas washing bottle,250mL
★接受瓶,250mL
In the receiving flask,250mL
★石英弯管
Of quartz tubes
★石英管
Of quartz tube
★石英舟
Of the quartz boat
★玻璃弯管(Φ5)
Glass pipe ( <5).
★电热丝(Φ0.5×Φ5.5×340)
Of electric wire ( <0.5 x <5.5x 340)
★电热丝(Φ0.5×Φ5.5×220)
Of electric wire ( <0.5 x <5.5x 220)
★热电偶
Of thermocouple
★Φ6×9乳胶管
In a6x 9milk hose
★橡胶塞
Of the rubber plug
★软木塞(小端Φ14)
In the cork ( small end diameter14)