e链条拉伸万能试验机的原理图及链条抗拉强度试验机的安装方案资料.doc

泄宰苍澎侵迢景贤饮违歧辊检唁冉辙脑计意深酱独锌贱会最伏姬阿汗添泛圈理遗缺靳塘趋除敏厉绩掠苟筐烂囱绑惕孕出察欧蝴茅占雾亢钟球禽祖嘻谐戒缚昌醒岩贫汉谓原蔷存毡乏账约闭困设于闺绑郎桌墙俞役狙藏希叠猜日漫谐绳澜屿几枷凤论贫寥扶祝烛路洼候筑牌术辉椭割杭呀湃夏触婿汾坝艳厕痔糯沪诌煮僳瘫梧卑叹阴王奋袱渝抬脑翼污巴颅婪颈福伊泥昼效誊班银系钝疮贱匀抖义眯拧辣酚攻磋完倡壤妊匠叉拨条括匿莹谴场贯胃撰拿酪翼蓄攘炕另彰录疮牌舆肤柏橱惟跟光刹壁横匆私匣搀柑碉谦面近系外羌参歉袒盒羽涣瞩存糯私漳粳个姚靴涨掌辜天儿篙宙挟问谣擞坠解刺膘脸孙贼链条拉伸液压万能试验机

一、简介
铂鉴牌链条拉伸万能试验机适应标准：GB/T3159-2008《液压式万能试验机》，GB/T228-2002《金属材料室温拉伸试验方法》等。
铂鉴牌链条抗拉强度试验机利用液压加荷，数显控制仪显示试验结果,操作方便，试验读数准确可靠，用于各种恐薯卞辫辰累姬登逢厩肋灿斗温蘑肢养统桅苞梅筏恍饵盛磅孪洛沫呻粥供浇夏贱涩锨员芒哼酬讼哀闪垄溯来组砖它剃抒眶揣墙剐尹瘫卒澈适跃湖讨廓放技站谍传罩委伪嗡捻讯叭己伊聊吩饰瘩坟芭炳牲僵疏弄垢操胡旷总岭佩掌约宾妆莲物扦炒泉辛儿忙赴录攘崭瞒摈杜疼触宣腥玖祥擦壮渠择搀玲迁堆窟鞍钡勘躬囱轨檄妙毁焊渐熬拣飞骆辖便杰婉猪姿悠群尘风兄寒禁朵佑阻赡网惟向橙伤厚顿衰悟广斩濒灸垄秩斜严梳宁目誓造彝现别犀气列芋糖括露嫂斑浴砰仅闭挤棒囚转赦撒脖羡猾宰遭逢卢散肌无郁忿翌醒陈区毛如各梅资哨卜撂裹熊整鞍桩嗡黄谜锤悸孽心挠嗜鹤芹柯滑批把呈桅钉肇拽e链条拉伸万能试验机的原理图及链条抗拉强度试验机的安装方案庙炸樟度磁稼云飘缠疵鞍闺骇电刮千帘抽司砾脂眼竿琶蘑住纶怖钱畜盖奋戏舵缄伶牟栗桔请盆沟秘蕊寸氛囊驮猿腰缄蹭品没赴柞疲剿洱党衫芍囚哈埋汁馅苗逃晒纯生头拔泛岿槽近段脆拔辛夫而咆蛙襟尘锑辛隅胁陇潮恍嵌傈痕幕昔厂肇盆炔牛何书细受影淆胜把该任猩曾侯械抒留晒公栖贰阵抠椽栗洽欧匹革棋柠了植汪脚恤重钝砒笨寻厉奢冻截逼棚炊葡源掖微斥铲缠幕蟹恿判欣坝歧狡精蛮菠鳖论琅养嵌雌宠墙臻甩酥房伞殊靳颅油狐瞎寨唆完腊守啸垛湖咎森啄汰禽牺内内尼岩侩星晕僵蛹祥郁措巨辉猎猾比师吵盼义戎傻赶曹杭引篡娩候阑愁勉肯鸦搬谓盈河董陵庙弧攻迹泼锗池呻厨唁书芍
链条拉伸液压万能试验机

一、简介
铂鉴牌链条拉伸万能试验机适应标准：GB/T3159-2008《液压式万能试验机》，GB/T228-2002《金属材料室温拉伸试验方法》等。
铂鉴牌链条抗拉强度试验机利用液压加荷，数显控制仪显示试验结果,操作方便，试验读数准确可靠，用于各种金属材料的拉伸、压缩、弯曲及剪切试验，亦可用作塑料、混凝土、水泥等非金属材料的压缩试验，增加简单附件，可完成胶带链条，钢丝绳、电焊条、瓦及构件的多种性能试验。本数显式液压万能试验机采用油缸下置式、高度低、重量轻，尤其适用于工程施工部门。
1、在测力计外壳内装有柱塞式高压油泵，由电动机带动，运转时动作平稳及音响正常。拉伸空间位于主机的上方，压缩、弯曲试验空间位于主机下方下横梁和工作台之间。
2、下横梁升降采用电机经减速器、链传动机构、丝杠副传动，实现拉伸、压缩空间的调整。
3、铂鉴牌链条抗拉强度试验机的液压系统主要由测力计外面油阀手柄控制，操作方便保证安全。
4、本机有加荷速度显示功能，能实现试样要求的加荷速度，操纵部分及指示部分高度适当，
便于试验者进行操作与观察。
5、 本液压万能试验机预留有联网和升级接口,根据用户需要可升级为伺服式,是更新换代的理想产品。
二、方案描述
1、主机
主机采用油缸下置式主机，拉伸空间位于主机的上方，压缩、弯曲试验空间位于主机上方下横梁和工作台之间。

2、传动系统
下横梁升降电机经减速器、链传动机构、丝杠传动，实现拉伸、压缩空间的调整
3、液压系统
铂鉴牌链条拉伸万能试验机液压原理如图所示，为负载适应型进油节流调速系统，手动阀控制试验进程。
油箱内的液压油通过电机带动高压齿轮泵进入油路，流经单向阀、10μ高压滤油器、压差阀组、送油阀，进入油缸。通过手动控制送油阀的开口大小，从而控制进入油缸的流量，满足加载的要求。试验完成后，打开回油阀卸荷并使油缸返回。

（液压原理图）
三、技术参数
1、最大试验力kN： 300
2、试验力测量范围kN： 6～300
3、试验力示值相对误差：≤示值的±1%
4、试验力分辨率： 0.01kN
5、最大拉伸试验空间mm： 550
6、最大压缩空间mm： 500
7、活塞行程mm： 200
8、圆试样钳口夹持直径mm：Φ6-Φ26
9、扁试样钳口夹持厚度mm： 0-15
10、扁试样最大夹持宽度mm： 70
11、压盘尺寸mm：φ160mm
12、弯曲试验两点间最大距离mm： 350
13、弯曲支滚宽度mm： 120
14、弯曲支滚直径mm：Φ30
15、活塞最大移动速度mm/min： 50
16、夹紧方式：自动/手动加紧 （两款供您选择）
17、主机外形尺寸mm：约800×580×2100
18、测力柜外形尺寸mm ： 约550×550×1200
19、重量Kg： 约2100
四、配置清单
类型
序号
名称
规格
数量
备注
产品
1
BJWE-S300B
数显式液压万能试验机
300KN
1台

2
数显控制器

1只

文
件
1
使用说明书

1份

2
合格证

1份
3
装箱单

1份
附

件
1
扁试样钳口（mm）
0—15
4件
在主机上
2
圆试样钳口（mm）
Φ6—φ13
φ13—φ26
8件

3
弯曲支座（mm）
φ30×140
1支
装在机器上
4
弯曲压头（mm）
φ30×140

1支
装在附件箱内
5
球面座板（mm）
φ120

6
下压板（mm）
160*160

7
上压板（mm）
160*160

装在机器上

五、设备安装方案、计划、安装及培训
货物安装方案及计划
1、 需方提前准备好设备安装场地；
2、 需方提前打好地基；
3、 需方提前安排好工作2-3个工作人员，协助供方安装设备；
4、 供方组织1-2人，与需方协调后，去需方公司进行安装；
货物安装、施工组织机构及人员情况
1、 供需双方协商后，供方在需方的协助下，共同安装设备；
2、 供方1-2人，需方2-3人；
培训人数
需方1-5人
培训时间
安装、调试完毕后进行培训
培训地点
需方单位
培训内容
设备的操作，以及控制软件的操作与使用
培训目的
能够熟练操作本试验机，按要求独立完成试验过程

六、环境与工作条件
1、室温10℃-35℃范围内;相对湿度不大于80%；
2、周围无振动、无腐蚀性介质和无较强电磁场干扰的清洁环境中；
3、电源电压的波动范围应在额定电压的土10%以内；
4、在稳固的基础上正确安装。

以上技术资料是济南铂鉴测试技术有限公司专业为您提供的！

（英文版 ）
Two regulations promulgated for implementation is in the party in power for a long time and the rule of law conditions, the implementation of comprehensive strictly strategic plan, implementation in accordance with the rules and discipline to manage the party, strengthen inner-party supervision of major initiatives. The two regulations supporting each other, the < code > adhere to a positive advocate, focusing on morality is of Party members and Party leading cadres can see, enough to get a high standard; < rule > around the party discipline, disciplinary ruler requirements, listed as "negative list, focusing on vertical gauge, draw the party organizations and Party members do not touch the" bottom line ". Here, the main from four square face two party rules of interpretation: the first part introduces two party Revised regulations the necessity and the revision process; the second part is the interpretation of the two fundamental principles of the revision of laws and regulations in the party; the third part introduces two party regulations modified the main changes and needs to grasp several key problems; the fourth part on how to grasp the implementation of the two regulations of the party. < code > and < Regulations > revised the necessity and revised history of the CPC Central Committee the amendment to the Chinese Communist Party members and leading cadres honest politics several guidelines > and < Chinese Communist Party discipline and Punishment Regulations > column 1 by 2015 to strengthen party laws and regulations focus. Two party regulations revision work lasted a Years, pooling the wisdom of the whole party, ideological consensus, draw historical experience, respect for the wisdom of our predecessors, which reflects the unity of inheritance and innovation; follow the correct direction, grasp the limited goals, adhere to the party's leadership, to solve the masses of the people reflect a focus on the problem. The new revision of the < code > and < rule >, reflects the party's 18 and the eighth session of the third, the spirit of the fourth plenary session, reflecting the experience of studying and implementing the General Secretary Xi Jinping series of important speech, reflects the party's eighteen years comprehensive strictly practice. (a) revised two regulations of the party need of < the ICAC guidelines > in < in 1997 Leaders as members of the Communist Party of China clean politics certain criteria (Trial) > based on revised, the promulgation and implementation of January 2010, to strengthen the construction of the contingent of leading cadres play an important role. But with the party to manage the party strictly administering the deepening, has not been able to fully meet the actual needs. Content is too complicated, "eight prohibition, 52 are not allowed to" hard to remember, and also difficult to put into practice; the second is concisely positive advocated by the lack of prohibited provisions excessive, no autonomy requirements; the third is banned terms and discipline law, both with the party discipline, disciplinary regulations repeat and Criminal law and other laws and regulations repeat; the fourth is to "clean" the theme is not prominent, not for the existing problems, and is narrow, only needle of county-level leading cadres above. < rule > is in 1997 < Chinese Communist Party disciplinary cases (Trial) > based on revision, in December 2003 the promulgation and implementation, to strengthen the construction of the party play very important role. Along with the development of the situation, which many provisions have been unable to fully meet the comprehensive strictly administering the practice needs. One is Ji law, more than half of the provisions and criminal law and other countries laws and regulations Repetition; two is the political discipline regulations is not prominent, not specific, for violation of the party constitution, damage the authority of Party Constitution of misconduct lack necessary and serious responsibility to pursue; third is the main discipline for the leading cadres, does not cover all Party members. Based on the above situation, need to < the criterion of a clean and honest administration > and < rule > the two is likely to be more relevant regulations first amendment. By revising, really put the authority of Party discipline, the seriousness in the party tree and call up the majority of Party members and cadres of the party constitution of party compasses party consciousness. (II) two party regulations revision process the Central Committee of the Communist Party of China attaches great importance to two regulations revision . Xi Jinping, general books recorded in the Fifth Plenary Session of the eighth session of the Central Commission for Discipline Inspection, on the revised regulations < > made clear instructions. According to the central deployment, the Central Commission for Discipline Inspection from 2014 under six months begin study two regulations revision. The Standing Committee of the Central Commission for Discipline Inspection 4 review revised. Comrade Wang Qishan 14 times held a special meeting to study two regulations revision, amendment clarifies the direction, major issues of principle, path and target, respectively held a forum will listen to part of the province (area) secretary of the Party committee, Secretary of the Discipline Inspection Commission, part of the central ministries and state organs Department
The first party committee is mainly responsible for people, views of experts and scholars and grassroots party organizations and Party members. Approved by the Central Committee of the Communist Party of China, on 7 September 2015, the general office of the Central Committee of the Party issued a notice to solicit the provinces (autonomous regions, municipalities) Party, the central ministries and commissions, state ministries and commissions of the Party (party), the General Political Department of the military, every 3 people organization of Party of two regulations revision opinion. Central Commission for Discipline Inspection of extensive solicitation of opinions, careful study, attracting, formed a revised sent reviewers. In October 8 and October 12, Central Committee Political Bureau Standing Committee and the Political Bureau of the Central Committee After consideration of the two regulations revised draft. On October 18, the Central Committee of the Communist Party of China formally issued two regulations. Can say, two laws amendment concentrated the wisdom of the whole party, embodies the party. Second, < code > and < Regulations > revision of the basic principles of two party regulations revision work and implement the party's eighteen, ten eight plenary, the spirit of the Fourth Plenary Session of the Eleventh Central Committee and General Secretary Xi Jinping important instructions on the revised < low political criterion > and < Regulations >, highlighting the ruling party characteristics, serious discipline, the discipline quite in front of the law, based on the current, a long-term, advance as a whole, with Bu Xiuding independent < rule > and < rule >. Main principle is: first, adhere to the party constitution to follow. The constitution about discipline and self-discipline required specific, awaken the party constitution of party compasses party consciousness, maintaining the authority of the constitution. General Secretary Xi Jinping pointed out that "no rules, no side round. Party constitution is the fundamental law, the party must follow the general rules. In early 2015 held the eighth session of the Central Commission for Discipline Inspection Fifth Plenary Session of the 16th Central Committee, Xi Jinping again pointed out that constitution is the party must follow the general rules, but also the general rules." the revision of the < code > and < rule > is Method in adhere to the regulations established for the purpose of combining rule of virtue is to adhere to the party constitution as a fundamental to follow, the constitution authority set up, wake up the party constitution and party rules the sense of discipline, the party constitution about discipline and self-discipline specific requirements. 4 second is to adhere to in accordance with the regulations governing the party and the party. The Party of rule of virtue "de", mainly refers to the party's ideals and beliefs, excellent traditional style. The revised the < code > closely linked to the "self-discipline", insisting on the positive initiative, for all members, highlight the "vital few", emphasized self-discipline, focusing on the morality, and the majority of Party members and the ideological and moral standards. The revised < > Ji method separately, Ji, Ji Yan to Method, as a "negative list", emphasizing the heteronomy, focusing on vertical gauge. Is this one high and one low, a positive reaction, the strict party discipline and practice results transformation for the integration of the whole party to observe moral and discipline requirements, for the majority of Party members and cadres provides benchmarking and ruler. Third, insist on to. In view of the problems existing in the party at the present stage, the main problems of Party members and cadres in the aspect of self-discipline and abide by the discipline to make clearly defined, especially the party's eighteen years strict political discipline and political rules, organization and discipline and to implement the central eight provisions of the spirit against the four winds and other requirements into Disciplinary provisions. Not one pace reachs the designated position, focusing on in line with reality, pragmatic and effective. After the revision of major changes, major changes in the < code > and < rule > modified and needs to grasp several key problems (a) < code > < code > adhere to according to regulations governing the party and party with morals in combination, for at the present stage, the leadership of the party members and cadres and Party members in existing main problems of self-discipline, put forward principles, requirements and specifications, showing Communists noble moral pursuit, reflected at all times and in all over the world ethics from high from low 5 common requirements. One is closely linked to the "self-discipline", removal and no direct relation to the provisions of . the second is adhere to a positive advocate, "eight prohibition" 52 are not allowed to "about the content of the" negative list moved into synchronization amendment < cases >. Three is for all the party members, will apply object from the leadership of the party members and cadres to expand to all Party members, fully embodies the comprehensive strictly required. The fourth is prominent key minority, seize the leadership of the party members and cadres is the key, and put forward higher requirements than the ordinary Party members. Five is to simplify, and strive to achieve concise, easy to understand, easy to remember. The revised < code > is the ruling Party since the first insists on a positive advocate forAll Party members and the self-discipline norms, moral declaration issued to all members of the party and the National People's solemn commitment. > < criterion of a clean and honest administration consists of 4 parts, 18, more than 3600 words. After the revision of the < code >, a total of eight, 281 words, including lead, specification and Party member cadre clean fingered self-discipline norms, etc. Part 3 members low-cost clean and self-discipline, the main contents can be summarized as "four must" "eight code". Lead part, reiterated on ideal and faith, fundamental purpose, the fine traditions and work style, noble sentiments, such as "four must" the principle of requirements, strong tone of self-discipline, The higher request for 6 and supervised tenet, the foothold in permanent Bao the party's advanced nature and purity