级配砂砾底基层施工方案.docx

级配砂砾路面底基层施工方案一、装载机4台，振动压路机1台，轮式单轮振动压路机1台，自卸汽车4辆、洒水车1台、平地机、刮平面1台等。 四、施工准备1、土方路基验收:已形成路基的压实度、平整度、纵断高程、宽度、厚度、横坡、弯沉等技术指标经自检合格后报监理工程师抽查,经抽检各项指标符合规范要求。2、级配砂砾底面基层各项试验按照试验规程已完成，附试验资料。3、施工放样：在达到标准的路基上恢复中线，直线段每25m设一桩，曲线段每20m设一桩，并在两侧边缘外设指示桩。在两侧指示桩上用明显标记标出级配砂砾底基层的设计标高。五、级配砂砾底面层施工工序 1施工工艺路槽验收准备集料摊铺整平洒水碾压质量检查洒水养生。2施工方案 通过自卸汽车运输,机械摊铺，2个施工作业队交替配合装载机粗平、平地机精平、机械压实。碾压成型的底基层采用自喷式洒水车洒水养生的方案。3施工方法：1）路槽准备在铺筑天然砂砾垫层之前，应从填筑好的路床上将所有浮土、杂物清除干净，并严格整形和压实，使其达到设计所规定的要求。路槽上的车辙、松软部分和压实不足的地方，以及任何不符合规定要求的表面都应翻松、清除或掺添同类材料，重新进行整修，使其达到规范要求。2）集料准备天然砂砾面层所用砂砾在调查试验并进行试配和标准击实的基础上，确认合格后方可进料。各种材料均按指定料场用汽车运输到工地。材料设专人管理、专人验收，严把质量关。3）摊铺、整平摊铺时的砂砾料含水量略高于压实时的最佳含水量,以弥补施工过程中的水分损失。装载机将运至现场的砂砾料推平,用平地机粗平,人工根据设计高程和摊铺系数挂左、中、右三条线（弯道加宽超高部分挂“米”字线）进行精平,以确保表面平整，厚度均匀， 横坡标准。摊铺系数经试验后，在1.251.30之间，具体数值我们在施工过程中根据实际测试后确定。整形过程为：平地机粗平人工挂线精平振动压路机稳压人工配合平地机修整缺陷处检查平整度、厚度及横坡和路拱进入碾压工序。4）压实摊铺整形完成后，如级配砂砾含水量较小，可进行补充洒水，使其达到最佳含水量。发现集料离析时，要及时进行处理，对过细或过粗材料，应掺入适用的材料或挖除重新填筑。压实采用先振动后静压，碾压方向均应与中线平行，直线段由边到中，由慢到快，超高段由内向外依次进行碾压。碾压时后轮重迭1/3轮宽，且必须超过两接缝处，直至压实度不小于96%。成型后的垫层应表面平整，无明显轮迹，具有标准的横坡和路拱。5）质量检查对砂砾面层压实度、平整度、高程、厚度、横坡、宽度进行自检，并提交监理工程师抽检审查批准后，方可进行下道工序施工。6）养生养生时控制洒水量，使砂砾面层表面保持湿润，不得有积水现象。碾压结束后经自检合格报请监理工程师检查验收，验收合格，及时进行养生。三、级配砂砾底面层施工注意事项（1）检查密实度 密实度96%。采用灌砂法检查，每车道每200m检查个点。 （2）依据铺筑路段确定的松铺系数，计算出控制摊铺标高数据，在各桩测出后挂线、摊铺、整平、碾压。（3）摊铺级配砂砾面基层施工采用全幅摊铺，装载机摊铺后，人工配合平地机整平。安排专人负责摊铺厚度、平整度、横坡等指标的控制，发现问题及时反映，以免影响砂砾面层的摊铺质量。摊铺时应注意天气变化，对天气预报有雨的天气做好充分准备工作，确保摊铺有序进行，压路机要及时碾压成型。（4）压实摊铺后紧跟碾压工序，碾压严格遵循先慢后快、先轻后重、由低到高的原则。碾压顺序：振动稳压振动振压光轮压路机压实振动复压。碾压时，根据摊铺速度及蒸发量大小，确定适宜的压实段落，避免水分散失过多及压实段落太长而造成的含水量不够或砂砾面层平整度的降低。碾压时，压路机应缓起慢行、稳停，走向要直，速度要均匀，力求避免压路机的停止位置在同一断面上，而造成该断面出现台阶现象。四、质量、安全保证体系（一）质量保证体系框图质量保证组织机构项目经理 技术负责人 生产部技术部质检部材料员质检员、试验员技术员、资料员 工程施工队材料质检员班组质检员工程技术质检员质量保证体系图质量合格证体系思想体系控制体系组织体系项目经理部施工组织设计与方案控制预防为主的方针质量意识教育质 检 组施工队、机械队各工程分队质检员质量信息反馈机具材料的质量控制施工准备与质量控制施工过程的质量控制质检部机械队施工技术部（二）质量保证措施 为了保证工程质量，我方将在项目负责人的领导下，作到层层有人管、事事有人抓，工程质量进行全方位的控制，配合驻地监理的工作。 （1）施工方法：砂砾面层是公路路面工程的重要组成部分，要满足设计和使用要求，必须要有足够的强度和稳定性才保证路面稳定，因而砂砾底面层必须保证施工质量。填料、整平必须挂线施工，严格控制标高、宽度和平整度。施工路段要架设水准仪随时检测、调整。整平后，在最佳含水量进行碾压，机械组合和碾压遍数必须按规定进行。压实度达到设计要求后前移工作面。（2）技术措施：在路面砂砾面层施工前，试验人员到所有业主指定的料场取样，按照设计文件的要求对砂砾料的各项指标进行试验。在填筑时，利用装载机配合平地机按照设计的路拱横坡进行整平。填筑达到设计标高时，先用振动压路机稳压两遍后用平地机刮平，再用水准仪及三米直尺对路线高程、路拱及平整度等指标不符合要求之处进行全面修整，然后进行碾压工作。碾压成型后再进行复测、修整。（三）工期保证措施1、调遣精兵强将，强化施工管理。2、科学组织、精心施工，加强施工计划的科学性，运用统筹法、网络技术、系统工程等新技术编制切实可行的实施性施工组织设计，选择最优施工方案。3、应用高效先进的生产设备及采用先进合理的施工工艺。4、采取有力措施搞好夏季与雨季施工5、搞好环境保障，减少施工干扰6、抓住时机，掀起施工高潮7、保证工期的主要施工组织技术措施（1）强化指挥机构（2）投入精锐力量（3）抓紧施工准备。（4）施工组织不断优化，搞好调整，优化施工组织方案，使之更趋完善、合理。（5）施工调度做到高效运转（6）协调好季节施工。（7）加强设备管理和调配。（8）保障材料供应对所需材料做到有组织、有计划地进行采购与供应、储备，保证施工用料。（四）安全保证体系安全保证体系项目经理、副经理生产负责人安 全 员施工负责人预 制 厂 长施 工 队 长机 械 队 长（五）保证安全的措施1、安全目标实现“五无”即无职工死亡、无重大行车事故、无重大交通责任事故、无重大质量火灾事故、无重大机械事故。2、组织保证（1）认真贯彻、严格执行安全工作制度，成立安全管理小组，制定技术措施和岗位责任制。（2）加强安全工作组织领导，从月抓起，以月保季、以季保年。（3）经常广泛开展安全事故教育活动，增强干部和职工的安全意识，做到“三个坚持”和“四个加强”，即：“三个坚持”坚持安全第一的思想，坚持预防为主的原则，坚持三不放过的制度。“四个加强”加强安全工作的领导，充分发挥各方面、各部门的作用；加强组织纪律和法制教育，提高安全生产的自觉性；加强安全检查工作，及时消灭事故隐患，加强自身建设，不断提高队伍素质。（六）工作保证（1）施工中必须向员工进行安全技术交底，制定安全操作规程。（2）对特殊岗位的操作工人要做到持证上岗，指各类机械驾驶员、修理工等。（3）做好各种标志牌：在工程现场周围设置并维护必要标志牌，包括警告与危险标志、指路标志、限速标志。（4）对机械设备、电器设备进行安全检查，定期维护。（5）夜间施工时，夜间要有足够的照明标志。（6）要有防火灾措施。油库、机械停放及维修地点、可燃物的堆放和存放处，均需有灭火装置。五、 文明施工措施1、便道设专职人员,疏导交通,不允许因施工面造成车辆堵塞现象发生。2、我项目部将完善以往不足的管理制度，要求施工现场管理人员一律佩证上岗，并署明姓名，职务，上岗期间一律穿著整齐。3、施工现场安排具有较强责任心且强经验丰富的施工人员担任安全员，负责人身安全保护与事故预防及安全检查，检查所有安全规则及条例的执行情况。4、在业主划定的施工区范围内进行各种作业，不对施工区界限以外的自然地貌进行改变和破坏。5、施工机械分类划区停置并设专人指挥、管理。所有机械、车辆定期检修，并按待修、停驶、运转不同状态划定停放区域，并标牌示位。6、建立各种规章制度和明确的交接班制度，使各项工作紧而有序，忙而不乱。7、要求对临时便道经常进行洒水整修养护，因施工造成的污水及垃圾应及时排出和运至弃土场。8、完善组织，保证体系，明确职责。值班经理做到每天至少现场巡视一次，保证各施工班组实现文明施工。9、加强施工组织，尽可能缩小工作面，做到集中、快速，结束一段，清理一段。10、施工区的临时道路上应设置带有照明设备的安全标志，交通高峰期间，控制或减少材料运输车辆的出入，以免车辆拥挤和发生交通事故。主要施工机械表机械名称规格型号额定功率（KW）或容量（m3）或吨位（t）数量（台）挖掘机CAT320BL美国165KW2装载机ZL50C厦门112KW4振动压路机YZ16B洛阳1振动压路机YZ18B洛阳1光轮压路机3Y1821洛阳1平地机DZ1801自卸车红岩重庆8T4洒水车CA-10B武汉6T1天然砂砾面层施工工艺框图路基验收整修路槽砂砾料运输碾压压实度检查养生验收备料检验合格确定松铺系数闷料（英文版 ） Two regulations promulgated for implementation is in the party in power for a long time and the rule of law conditions, the implementation of comprehensive strictly strategic plan, implementation in accordance with the rules and discipline to manage the party, strengthen inner-party supervision of major initiatives. The two regulations supporting each other, the adhere to a positive advocate, focusing on morality is of Party members and Party leading cadres can see, enough to get a high standard; around the party discipline, disciplinary ruler requirements, listed as negative list, focusing on vertical gauge, draw the party organizations and Party members do not touch the bottom line . Here, the main from four square face two party rules of interpretation: the first part introduces two party Revised regulations the necessity and the revision process; the second part is the interpretation of the two fundamental principles of the revision of laws and regulations in the party; the third part introduces two party regulations modified the main changes and needs to grasp several key problems; the fourth part on how to grasp the implementation of the two regulations of the party. and revised the necessity and revised history of the CPC Central Committee the amendment to the Chinese Communist Party members and leading cadres honest politics several guidelines and column 1 by 2015 to strengthen party laws and regulations focus. Two party regulations revision work lasted a Years, pooling the wisdom of the whole party, ideological consensus, draw historical experience, respect for the wisdom of our predecessors, which reflects the unity of inheritance and innovation; follow the correct direction, grasp the limited goals, adhere to the partys leadership, to solve the masses of the people reflect a focus on the problem. The new revision of the and , reflects the partys 18 and the eighth session of the third, the spirit of the fourth plenary session, reflecting the experience of studying and implementing the General Secretary Xi Jinping series of important speech, reflects the partys eighteen years comprehensive strictly practice. (a) revised two regulations of the party need of in based on revised, the promulgation and implementation of January 2010, to strengthen the construction of the contingent of leading cadres play an important role. But with the party to manage the party strictly administering the deepening, has not been able to fully meet the actual needs. Content is too complicated, eight prohibition, 52 are not allowed to hard to remember, and also difficult to put into practice; the second is concisely positive advocated by the lack of prohibited provisions excessive, no autonomy requirements; the third is banned terms and discipline law, both with the party discipline, disciplinary regulations repeat and Criminal law and other laws and regulations repeat; the fourth is to clean the theme is not prominent, not for the existing problems, and is narrow, only needle of county-level leading cadres above. is in 1997 based on revision, in December 2003 the promulgation and implementation, to strengthen the construction of the party play very important role. Along with the development of the situation, which many provisions have been unable to fully meet the comprehensive strictly administering the practice needs. One is Ji law, more than half of the provisions and criminal law and other countries laws and regulations Repetition; two is the political discipline regulations is not prominent, not specific, for violation of the party constitution, damage the authority of Party Constitution of misconduct lack necessary and serious responsibility to pursue; third is the main discipline for the leading cadres, does not cover all Party members. Based on the above situation, need to and the two is likely to be more relevant regulations first amendment. By revising, really put the authority of Party discipline, the seriousness in the party tree and call up the majority of Party members and cadres of the party constitution of party compasses party consciousness. (II) two party regulations revision process the Central Committee of the Communist Party of China attaches great importance to two regulations revision . Xi Jinping, general books recorded in the Fifth Plenary Session of the eighth session of the Central Commission for Discipline Inspection, on the revised regulations made clear instructions. According to the central deployment, the Central Commission for Discipline Inspection from 2014 under six months begin study two regulations revision. The Standing Committee of the Central Commission for Discipline Inspection 4 review revised. Comrade Wang Qishan 14 times held a special meeting to study two regulations revision, amendment clarifies the direction, major issues of principle, path and target, respectively held a forum will listen to part of the province (area) secretary of the Party committee, Secretary of the Discipline Inspection Commission, part of the central ministries and state organs Department The first party committee is mainly responsible for people, views of experts and scholars and grassroots party organizations and Party members. Approved by the Central Committee of the Communist Party of China, on 7 September 2015, the general office of the Central Committee of the Party issued a notice to solicit the provinces (autonomous regions, municipalities) Party, the central ministries and commissions, state ministries and commissions of the Party (party), the General Political Department of the military, every 3 people organization of Party of two regulations revision opinion. Central Commission for Discipline Inspection of extensive solicitation of opinions, careful study, attracting, formed a revised sent reviewers. In October 8 and October 12, Central Committee Political Bureau Standing Committee and the Political Bureau of the Central Committee After consideration of the two regulations revised draft. On October 18, the Central Committee of the Communist Party of China formally issued two regulations. Can say, two laws amendment concentrated the wisdom of the whole party, embodies the party. Second, and revision of the basic principles of two party regulations revision work and implement the partys eighteen, ten eight plenary, the spirit of the Fourth Plenary Session of the Eleventh Central Committee and General Secretary Xi Jinping important instructions on the revised and , highlighting the ruling party characteristics, serious discipline, the discipline quite in front of the law, based on the current, a long-term, advance as a whole, with Bu Xiuding independent and . Main principle is: first, adhere to the party constitution to follow. The constitution about discipline and self-discipline required specific, awaken the party constitution of party compasses party consciousness, maintaining the authority of the constitution. General Secretary Xi Jinping pointed out that no rules, no side round. Party constitution is the fundamental law, the party must follow the general rules. In early 2015 held the eighth session of the Central Commission for Discipline Inspection Fifth Plenary Session of the 16th Central Committee, Xi Jinping again pointed out that constitution is the party must follow the general rules, but also the general rules. the revision of the and is Method in adhere to the regulations established for the purpose of combining rule of virtue is to adhere to the party constitution as a fundamental to follow, the constitution authority set up, wake up the party constitution and party rules the sense of discipline, the party constitution about discipline and self-discipline specific requirements. 4 second is to adhere to in accordance with the regulations governing the party and the party. The Party of rule of virtue de, mainly refers to the partys ideals and beliefs, excellent traditional style. The revised the closely linked to the self-discipline, insisting on the positive initiative, for all members, highlight the vital few, emphasized self-discipline, focusing on the morality, and the majority of Party members and the ideological and moral standards. The revised Ji method separately, Ji, Ji Yan to Method, as a negative list, emphasizing the heteronomy, focusing on vertical gauge. Is this one high and one low, a positive reaction, the strict party discipline and practice results transformation for the integration of the whole party to observe moral and discipline requirements, for the majority of Party members and cadres provides benchmarking and ruler. Third, insist on to. In view of the problems existing in the party at the present stage, the main problems of Party members and cadres in the aspect of self-discipline and abide by the discipline to make clearly defined, especially the partys eighteen years strict political discipline and political rules, organization and discipline and to implement the central eight provisions of the spirit against the four winds and other requirements into Disciplinary provisions. Not one pace reachs the designated position, focusing on in line with reality, pragmatic and effective. After the revision of major changes, major changes in the and modified and needs to grasp several key problems (a) adhere to according to regulations governing the party and party with morals in combination, for at the present stage, the leadership of the party members and cadres and Party members in existing main problems of self-discipline, put forward principles, requirements and specifications, showing Communists noble moral pursuit, reflected at all times and in all over the world ethics from high from low 5 common requirements. One is closely linked to the self-discipline, removal and no direct relation to the provisions of . the second is adhere to a positive advocate, eight prohibition 52 are not allowed to about the content of the negative list moved into synchronization amendment . Three is for all the party members, will